Table 2-5 Operator Preventive Maintenance Checks and Services - Continued

TM5--4210-224-14&P

Table 2-5 Operator Preventive Maintenance Checks and Services - Continued

D - Daily

W - Weekly

A-

After

M-

Monthly

PROCEDURES

EQUIPMENT IS

INTERVAL

ITEM

ITEM TO BE

Check for and have repaired

NOT READY/

NO. D A W M

INSPECTED

or adjusted as necessary

AVAILABLE IF

Panels, Front

Visually inspect panels and step assemblies for

Street Side,

structural damage.

and Step

Assemblies

Primer Tank

Visually inspect primer tank for leaks and structural

Oil level is

damage. Check oil level in primer tank.

low.

Level should be approximately one inch below full

level. Replenish as necessary using SAE-30 oil.

HOSE BODY ASSEMBLY

Handrails and

Visually inspect handrails and mounting brackets

Mounting

for structural damage.

Brackets

Lights

Perform operational checks on hose bed pick-up

Tail lights

lights, rear warning lights, tail lights and

are defective.

compartment lights. Inspect lights for defective

lamps, bulbs, or damaged lenses. Refer to next

higher level of maintenance for replacement or

repair.

Doors

Check operation and general condition of compartment

doors.

Panels, Side,

Visually inspect panels and tread plates for

Compartment

structural damage.

and Tread

Plates

Rear

Visually inspect rear compartment and rear platform

Compartment

assembly for structural damage. Perform

and Platform

operational checks on rear back-up alarm and

Assembly

rear platform signal switch. Visually inspect

rear station charger for structural damage.

19 q

Hose Bed

Visually inspect hose bed fill tower bracket,

Assembly

floor, and supports for structural damage.

FIREFIGHTING SYSTEM

Priming Pump

Perform operational check on priming pump motor.

Priming pump

Visually inspect pump for corrosion or structural

not operating.

damage. Refer to next higher level of maintenance

Priming pump

if any defects are found.

damaged.

Fire Pump

Perform operational check on fire pump. Visually

Fire pump not

inspect pump for corrosion or structural damage.

operating.

Refer to next higher level of maintenance if any

Fire pump damaged.

defects are found.

Tank, Valves,

Visually inspect tank, valves, control rods and

Tank, valves,

Control Rods,

piping for corrosion or structural damage. Refer

control rods

and Piping

to next higher level of maintenance if any defects

or piping

are found.

are damaged.

2-36